Food Establishment Inspection Report
Page 1  of ????????? 
OFFICE OF ENVIRONMENTAL SERVICES
21306 Illinois Route 9
Tremont, IL 61568-9252
Establishment
LEAVES 'N BEANS 		License/Permit #
1702
Street Address
730 W JACKSON ST
City/State
MORTON, IL 		ZIP Code
61550
No. of Risk Factor/Intervention Violations 2
No. of Repeat Risk Factor/Intervention Violations 0
Date 05/23/2023
Time In 11:25 PM
Time Out 12:45 PM
Permit Holder
JAMES CROSS 		Risk Category
Category I
Purpose of Inspection   Regular

FOODBORNE ILLNESS RISK FACTORS AND PUBLIC HEALTH INTERVENTIONS
Circle designated compliance status (IN, OUT, N/O, N/A) for each numbered item
IN=in compliance    OUT=not in compliance    N/O=not observed    N/A=not applicable
Mark "X" in appropriate box for COS and/or R
COS=corrected on-site during inspection    R=repeat violation 		Risk factors are important practices or procedures identified as the most prevalent contributing factors of foodborne illness or injury. Public health interventions are control measures to prevent foodborne illness or injury.
Compliance Status
 COS R

SUPERVISION

 
1 IN OUT     Person in charge present, demonstrates knowledge, and performs duties    
2 IN OUT N/A   Certified Food Protection Manager    

EMPLOYEE HEALTH

 
3 IN OUT     Management, food employee and conditional employee; knowledge, responsibilities and reporting    
4 IN OUT     Proper use of restriction and exclusion    
5 IN OUT     Procedures for responding to vomiting and diarrheal events    

GOOD HYGIENIC PRACTICES

 
6 IN OUT   N/O Proper eating, tasting, drinking, or tobacco use    
7 IN OUT   N/O No discharge from eyes, nose, and mouth    

PREVENTING CONTAMINATION BY HANDS

 
8 IN OUT   N/O Hands clean & properly washed    
9 IN OUT N/A N/O No bare hand contact with RTE food or a pre-approved alternative procedure properly allowed    
10 IN OUT     Adequate handwashing sinks properly supplied and accessible X  

APPROVED SOURCE

 
11 IN OUT     Food obtained from approved source    
12 IN OUT N/A N/O Food received at proper temperature    
13 IN OUT     Food in good condition, safe, & unadulterated    
14 IN OUT N/A N/O Required records available: shellstock tags, parasite destruction    
 
Compliance Status
 COS R

PROTECTION FROM CONTAMINATION

 
15 IN OUT N/A N/O Food separated and protected    
16 IN OUT N/A   Food-contact surfaces: cleaned & sanitized    
17 IN OUT     Proper disposition of returned, previously served, reconditioned & unsafe food    

TIME/TEMPERATURE CONTROL FOR SAFETY

 
18 IN OUT N/A N/O Proper cooking time & temperatures    
19 IN OUT N/A N/O Proper reheating procedures for hot holding    
20 IN OUT N/A N/O Proper cooling time and temperature    
21 IN OUT N/A N/O Proper hot holding temperatures    
22 IN OUT N/A N/O Proper cold holding temperatures    
23 IN OUT N/A N/O Proper date marking and disposition    
24 IN OUT N/A N/O Time as a Public Health Control; procedures & records    

CONSUMER ADVISORY

 
25 IN OUT N/A   Consumer advisory provided for raw/undercooked food    

HIGHLY SUSCEPTIBLE POPULATIONS

 
26 IN OUT N/A   Pasteurized foods used; prohibited foods not offered    

FOOD/COLOR ADDITIVES AND TOXIC SUBSTANCES

 
27 IN OUT N/A   Food additives: approved and properly used    
28 IN OUT N/A   Toxic substances properly identified, stored, & used X  

CONFORMANCE WITH APPROVED PROCEDURES

 
29 IN OUT N/A   Compliance with variance/specialized process/HACCP    

GOOD RETAIL PRACTICES
Good Retail Practices are preventative measures to control the addition of pathogens, chemicals, and physical objects into foods.
Mark "X" in box if numbered item is not in compliance       Mark "X" in appropriate box for COS and/or R      
COS
=corrected on site during inspection   
R
=repeat violation  
  COS R

SAFE FOOD AND WATER

 
30   Pasteurized eggs used where required    
31   Water & ice from approved source    
32   Variance obtained for specialized processing methods    

FOOD TEMPERATURE CONTROL

 
33   Proper cooling methods used; adequate equipment for temperature control    
34   Plant food properly cooked for hot holding    
35   Approved thawing methods used    
36   Thermometers provided & accurate    

FOOD IDENTIFICATION

 
37   Food properly labeled; original container    

PREVENTION OF FOOD CONTAMINATION

 
38   Insects, rodents, & animals not present    
39   Contamination prevented during food preparation, storage & display    
40   Personal cleanliness    
41   Wiping cloths: properly used & stored    
42   Washing fruits & vegetables    

PROPER USE OF UTENSILS

 
43   In-use utensils: properly stored    
 
  COS R

PROPER USE OF UTENSILS

 
44   Utensils, equipment & linens: properly stored, dried, & handled    
45   Single-use/single-service articles: properly stored & used    
46   Gloves used properly    

UTENSILS, EQUIPMENT, AND VENDING

 
47   Food & non-food contact surfaces cleanable, properly designed, constructed & used    
48   Warewashing facilities: installed, maintained & used; test strips    
49 X Non-food contact surfaces clean    

PHYSICAL FACILITIES

 
50   Hot & cold water available; adequate pressure    
51   Plumbing installed; proper backflow devices    
52   Sewage & waste water properly disposed    
53   Toilet facilities: properly constructed, supplied, & cleaned    
54   Garbage & refuse properly disposed; facilities maintained    
55   Physical facilities installed, maintained & clean    
56   Adequate ventilation & lighting; designated areas used    

EMPLOYEE TRAINING

 
57   All food employees have food handler training    

ALLERGEN AWARENESS & TRAINING

 
58   Allergen awareness and training    
IOCI 17-356

Food Establishment Inspection Report
Page 2  of ?????? 
Establishments: LEAVES 'N BEANS Establishment #: 1702
Water Supply:   Public Private   Waste Water System:   Public Private
Temperature Documentation: YES License Posted: YES Complaint Number:
Sanitation Information
Name: STEPHANIE BROWN    

SANITIZER OBSERVATIONS
Location Location Desc. Method Used Chemical Sanitizer Used PPM Water Temp
Sanitizer Bucket Front Counter Area Chemical Sanitizer Quaternary Ammonium 300.00 0.00
3-Compartment Sink Back Kitchen Area Chemical Sanitizer Quaternary Ammonium 200.00 0.00

TEMPERATURE OBSERVATIONS
Item/Location
Temp
Item/Location
Temp
Item/Location
Temp
Romaine Lettuce/Back Cooler 40.00°F Air Temperature/GE Cooler with Milk and Cold Brew 33.00°F Bacon/GE Cooler 35.00°F
Corn Salsa/Prep Cooler 36.10°F Heavy Cream/Mini Cooler - Front 34.00°F  

OBSERVATIONS AND CORRECTIVE ACTIONS
Item
Number 		Violations cited in this report must be corrected within the time frames below.
10 Observed the back hand sink without a supply of soap. Hand sinks must be stocked with soap and paper towels at all times.

Soap was supplied to the hand sink. Corrected on site.

- 6-301.11: Each HANDWASHING SINK or group of 2 adjacent HANDWASHING SINKS shall be provided with a supply of hand cleaning liquid, powder, or bar soap. - V,COS
28 Observed chemical spray bottle in the back kitchen area without a name label. Per the PIC, one is a quat sanitizer spray. Another bottle had a label that had faded and could not be read. Per the PIC, it was a soap mixture.

All working containers of chemicals and cleaning agents must be labeled with their common names. Container was labeled/re-labeled. Corrected on site.

- 7-102.11: Working containers used for storing POISONOUS OR TOXIC MATERIALS such as cleaners and SANITIZERS taken from bulk supplies shall be clearly and individually identified with the common name of the material. - V,COS
49 Observed the shelf with the microwave with food debris build up. Ensure the shelf is cleaned (including under the microwave) and maintained clean by the next routine inspection.

- 4-602.13: NonFOOD-CONTACT SURFACES of EQUIPMENT shall be cleaned at a frequency necessary to preclude accumulation of soil residues. - V
Inspection Comments Discussed date marking on deli meat. Deli meat comes frozen and sliced from another location. Ensure the deli meat is sliced and frozen the same day and remains frozen until it arrives to your facility. This will ensure the deli meat is only in the cooler for a total of 7 days.

The back freezer needs defrosted.
HACCP Topic: Discussed hand washing
 

Person In Charge (Signature)

  STEPHANIE BROWN 		 

Date:

  05/23/2023
 

Inspector

  Sarah Brubaker 		 

Follow-up:  Yes   No   Follow-up Date: